NPR News & More

In California, Air Tanker Pilots Help Keep Wildfires At Bay

By Matt Guilhem

Published October 29, 2019 at 4:25 PM EDT

Tanker 914 is operated by the Albuquerque-based 10 Tanker. It's one of four DC-10 jumbo jets converted to fight fires. The huge planes are 181 feet long and have a wingspan of 165 feet. Fully loaded before making a drop, the aircraft can tip the scale at 420,000 pounds.

High winds are in the forecast this week for all of California as fires burn up and down the Golden State. Near the Bay Area, the Kincade Fire has charred over 100 square miles, destroyed more than 120 structures and forced thousands to evacuate in the state's famed wine country. To the south, firefighters in Los Angeles are battling a number of blazes, including the Getty Fire in the hills near UCLA. Helping teams on the ground as they fight the flames is an arsenal of air support. The fires have prompted authorities to call in some of the biggest firefighting planes in operation.

About an hour east of Los Angeles, the three engines of Tanker 914 whine and fade as the jet comes to a halt on the tarmac at the former Norton Air Force Base in San Bernardino, Calif. The onetime military facility is now partially used as an air operations center for the U.S. Forest Service and hosts both firefighting helicopters and fixed-wing aircraft.

Inside, pilot Kevin Hopf explains why the main cabin is so roomy.

"You're standing in a Douglas DC-10 made in the mid-to-late '80s," Hopf says. "In its original passenger configuration it had about 350 seats."

Hopf is the lead pilot with 10 Tanker, a private company based in Albuquerque, N.M., that operates four of the firefighting jets. It contracts with government agencies such as the Forest Service and Cal Fire.

Taking in the plane's interior, it's ... spartan. No seats. No overhead bins. No nothing, really. Three big tanks attached to the outside of the plane hold the fire retardant. The minimal interior paired with a light fuel load makes for a pretty nimble jet.

"We're flying this airplane at about 200,000 pounds lighter than we normally did, which makes it very maneuverable," Hopf says. "Are there places that the helicopter can get to that we can't? Sure, absolutely. But it's a pretty small margin there of places that we can't put this airplane."

Some of the most remote terrain in canyons and on hillsides is where the plane shines. It drops its load of up to 9,400 gallons of Phos-Chek, the sticky red gel that helps keep fire at bay, from only a few hundred feet above the ground.

Over 9,000 gallons of Phos-Chek, an orange-red gel that slows the spread of fire, can be stored in three huge tanks attached to the bottom of the aircraft. All of the fire retardant stays outside the plane; what was the DC-10's cargo hold is now the home of hydraulic equipment that opens the tanks when the plane makes a drop.

"We get a lot of input as far as, 'How can you get that big of an airplane down that low to the ground?' " Hopf says. "The airplane doesn't know what's below it; it has no idea what kind of terrain we're flying over. We just need to keep it at a certain airspeed, which we do."

That airspeed is about 160 mph.

Hopf is passionate about his job; he has flown firefighting jets for 10 Tanker for more than a decade.

"I would not give this up to go back and fly the airlines," the longtime pilot says. "Airlines was fun, I enjoyed that, but now having done this, there's nothing that I'd rather do in an airplane than what I'm doing."

Outside the plane, standing in the jet's shadow, is Diego Calderoni, the co-captain of Tanker 914. Calderoni, too, relishes the harrowing profession he is in, but he is not sure how much the danger of his job registers with his family.

"I think they don't know what I do," Calderoni says. He pauses, then, says in fits and starts, "I mean, they'll see it on TV, but they don't know all the ... I mean, they do know it's dangerous. I've always been in forms of aviation of this sort, so they've gotten used to it. They know what I do, and they know I'm happy doing it."

He loves the work, knows the risks and gives up any sort of regular schedule to battle blazes across the country. Could he see himself in any other job?

The 30-something Calderoni heaves a sigh.

"Yeah? I don't know," he says with an uncertain chuckle. "I mean, once fire's in your blood, and you enjoy the mission of fire — it's hard to, it's hard to leave it."

Tanker 914 made several drops on the Getty Fire in LA on Monday morning before heading to Northern California to join suppression efforts there.

Strong winds that could rapidly push flames into homes are in the forecast for the rest of the week across the state, meaning more busy days for Calderoni and the crew.